Toyota RAV4 2019

Cold start completed. Idle settled normally as the engine warmed; no abnormal knock, persistent smoke or hesitation under the tested load.

Accessible hoses and radiator connections were dry. Coolant level and fan operation checked; engine temperature remained stable during warm-up and the road test.

D-003: Minor oil seepage reappeared near the upper engine after surface cleaning and warm-up. No dripping onto visible hot components observed. Trace the source and repair as required.

Scoring deduction: 0.4 points, counted at this node.

No fuel odour or visible leakage at accessible lines. Intake hoses and connections were secure; no persistent mixture issue noted in the available diagnostic readings.

No leakage or abnormal noise at accessible exhaust joints. No persistent smoke or active emissions warning during the tested operating modes.

No excessive engine movement or knock during gear selection and changes in load. Accessible mounts and fixings were secure.

Accessible drive belt and rollers showed no visible fraying or abnormal noise. A visual check does not establish their remaining service life.

Drive and reverse engaged without abnormal delay. Gear changes remained smooth during gentle and moderate acceleration.

Accessible transmission casing and connections were dry. Fluid level and visible condition checked using the applicable service procedure; no issue observed.

CV boots were intact with no visible grease leakage. Accessible shafts and final-drive housings checked; no abnormal driveline noise or binding during turns.

D-001: Rear brake pads show advanced wear. Replace the pads and recheck braking before normal use; verify disc condition and vehicle-specific wear limits during repair. Both rear wheels are counted as one repair problem.

Scoring deduction: 1.8 points, counted at this node.

Reservoir level, accessible lines and pedal response checked. No visible fluid leakage; brake assistance operated normally.

No pull or abnormal vibration during the road-test braking checks. Parking brake held the vehicle. Repeat the braking check after rear pad replacement.

Steering assistance and return were consistent, with no excessive free play observed. The vehicle tracked normally on the available road surfaces.

D-002: Minor play at the front-left stabiliser bush on the lift check. A corresponding light knock was reproduced on uneven road surfaces. Counted once at this node.

Scoring deduction: 0.5 points, counted at this node.

No visible damper oil leaks or broken springs. No abnormal rebound or noticeable side-to-side ride-height difference.

SRS warning completed its start-up self-check and went out. No active fault in the accessible SRS scan. Hidden airbags and concealed components were not physically verified.

ABS and stability-control warning self-checks were normal. Available diagnostic records and road-test observations showed no current issue; emergency intervention was not induced.

Accessible belts, buckles and mounting points checked. Retraction, fastening and buckle release operated normally.

Low-voltage supply and charging behaviour checked at rest and with the engine running. No starting difficulty or charging warning observed.

Exterior lighting, horn, wipers and washers operated normally.

D-004: Rear-left parking sensor did not respond during the functional test. Other checked sensors, camera, windows, locks and display functions operated. Diagnose the sensor and circuit, then recheck the parking system.

Scoring deduction: 0.6 points, counted at this node.

A/C operation and outlet cooling checked after stabilisation, both stationary and during the road test. No abnormal compressor noise observed.

D-005: Slightly reduced airflow from the passenger-side face vent compared with the other face vents at the same setting. Controls operated; inspect the air path and flap operation during planned maintenance.

Scoring deduction: 0.2 points, counted at this node.

Tyre sizes, markings, date codes, tread condition and pressures checked. No visible bulges, exposed cords or significant uneven wear.

Accessible rims and wheel fixings checked. No visible cracks or significant deformation.

Spare wheel was securely retained; inflation and visible condition checked. Jack and wheel wrench present.